Yamaha YP20G, YP30G v4 Owner's Manual PDF

Pages 38
Year 2005
Language(s)
English en
1 of 38
1 of 38

Summary of Content for Yamaha YP20G, YP30G v4 Owner's Manual PDF

Page 3

INTRODUCTION Congratulations on your purchase of your new Yamaha... This manual will provide you with a good basic understanding of the operation and maintenance of this machine... If you have any questions regarding the operation or maintenance of your machine, please consult a Yamaha dealer...

Page 4

ments in product design and quality... Therefore, while this manual contains the most current product information available at the time of printing, there may be minor discrepancies between your engine and this manual... If there is any question concerning this manu- al, please consult your Yamaha deal- er...

Page 5

LABELS ... 3

Page 6

WARRANTY TRANSFER; To transfer the war- ranty from the original purchaser to any subse- quent purchaser(s), it is imperative that the unit be inspected and registered for warranty by an authorized Yamaha water pump dealer... In order for this warranty to remain in effect, this inspection and registration must take place within (10) days after transfer... A reasonable dealer-imposed fee may be charged for the inspection... In no case will the warranty be extended beyond the original peri- od...

Page 7

CHANGE OF ADDRESS The federal government requires each manufacturer to maintain a complete, up-to- date list of all first purchasers against the possibility of a safety-related defect and recall... This list is compiled from the purchase registrations sent to Yamaha Motor Corporation, U... S... A... by the selling dealer at the time of your purchase... If you should move after you have purchased your new water pump, please advise us of your new address by sending a postcard listing your Yamaha model name, engine number, dealer number (or dealers name) as it is shown on your warranty identification, your name and new mailing address... Mail to: YAMAHA MOTOR CORPORATION, U... S... A...

Page 8

SESAE 10W-30 THIS ENGINE MEETS zzzz-zzzz CALIFORNIA EMISSION REGULATIONS FOR SMALL OFF-ROAD ENGINES... THIS ENGINE CONFORMS TO PHASE 2 U... S... EPA REGULATIONS FOR SMALL NONROAD ENGINES... EMISSIONS COMPLIANCE PERIOD:CATEGORY A (EPA) zzz-zzzzz-zz

Page 9

any to get in your eye(s), see your doctor immedi- ately... If any fuel spills on your skin or clothing, immediately wash with soap and water and change your clothes...

Page 10

a 9 Keep the machine at least 1 m (3 ft) from buildings

Page 11

1 Fuel tank 2 Fuel tank cap 3 Fuel cock 4 Air filter cover 5 Spark plug 6 Muffler 7 Choke lever 8 Engine switch 9 Oil filler cap 0 Oil drain plug q Recoil starter w Oil warning light e Throttle lever r Priming plug t Water drain plug

Page 12

NOTE: If the engine stalls or does not start, turn the engine switch to ON position and then pull the recoil starter... If the oil warning light flickers for a few seconds, the engine oil is insufficient... Add oil and restart...

Page 13

ENGINE SWITCH The engine switch controls the ignition system... 1 ON Ignition circuit is switched on... The engine can be started... 2 OFF Ignition circuit is switched off... The engine will not run...

Page 14

w The engine and muffler will be very hot after the engine has been run... Avoid touching the engine and muffler while they are still hot with any part of your body or clothing during inspection or repair...

Page 15

cC Be sure the pump is filled up with water before starting the engine or mechanical seal damage will occur...

Page 16

near to available water source as possible... 9 The higher the suction head is the more time will

Page 17

NOTE: The choke is not required to start a warm engine... Turn the choke lever to the operating position...

Page 18

6... After the engine starts, warm up the engine until the engine does not stop when the choke lever is returned to the operating position...

Page 19

DRAIN OF WATER AFTER USE Water inside casing freezes at below 0C (32F) in winter and thereby pump may possibly be broken... After use, drain water from drain port at bottom to store...

Page 20

cC Use only Yamaha specified genuine parts for replacement... Ask an authorized Yamaha dealer for further attention...

Page 21

CARBURETOR ADJUSTMENT The carburetor is a vital part of the engine... Adjusting should be left to a Yamaha dealer with the profession- al knowledge, specialized data, and equipment to do so properly...

Page 22

2... Remove the oil filler cap... 3... Place an oil pan under the engine... Remove the oil

Page 23

AIR FILTER 1... Remove the air filter cover and element... 2... Wash the element in solvent and dry... 3... Oil the element and squeeze out excess oil...

Page 24

1... Stop the engine... 2... Turn the fuel cock lever to OFF... 3... Remove the fuel cock cup and gasket... 4... Clean the cup with solvent and wipe it off... 5... Check the gasket... Replace it if damaged... 6... Reinstall the gasket and fuel cock cup...

Page 25

w The engine and muffler will be very hot after the engine has been run... Avoid touching the engine and muffler while they are still hot with any part of your body or clothing during inspection or repair...

Page 26

6... Install the spark arrester... NOTE: Align the spark arrester projection with the hole in the muffler pipe...

Page 27

Water does not draw up 2 Loosened priming and/or drain plugs ... Tighten... 2 Loosened hose joint and/or band ... Tighten... 2 Damaged O-ring and/or gaskets ... Replace 2 Damaged mechanical seal ... Consult dealer...

Page 28

9 To prevent FIRE HAZARDS be sure to place the spark plug as far way as possible from the spark plug hole and carburetor area...

Page 29

spoon of SAE 10W30 or 20W40 motor oil into spark plug hole and reinstall the spark plug... Recoil start the engine by turning over several times (with ignition off) to coat the cylinder walls with oil...

Page 30

The above items and the corresponding acronyms are provided in accordance with U... S... EPA REGULATIONS FOR NEW NONROAD SPARK-IGNITION NONHANDHELD ENGINES and the CALIFORNIA REGULATIONS FOR 1995 AND LATER SMALL OFF- ROAD ENGINES... The acronyms conform to the latest version of the SAEs recommended practice docu- ment J1930, Diagnostic Acronyms, Terms, and Definitions For Electrical/Electronic System...

Page 31

Rated Output kW(HP)/rpm 2... 0 (2... 7)/3,600 3... 3 (4... 4)/3,600 Operation Hours Hr 5... 1 3... 4 Fuel Unleaded gasoline Fuel Tank Capacity L (Imp gal, US gal) 4... 5 (0... 99, 1... 19) 4... 5 (0... 99, 1... 19) Engine Oil Quantity L (Imp qt, US qt) 0... 6 (0... 53, 0... 63) 0... 6 (0... 53, 0... 63) Ignition System TCI

Page 32

1 Oil warning light 2 Engine switch 3 TCI unit 4 Spark plug 5 Oil level switch 6 Oil warning unit

Page 36

LIT-19626-01-25 9CB-28199-10PRINTED ON RECYCLED PAPER 05 905 PDF 1 !

Page 37

YAMAHA MOTOR CORPORATION U... S... A... P... O... BOX 6555 CYPRESS, CALIFORNIA 90630

Page 38

9 Manufacturers are required to maintain a complete up-to-date list of all first purchasers of products against the possibility of a safety-related defect and recall...

Manualsnet FAQs

If you want to find out how the YP20G Yamaha works, you can view and download the Yamaha YP20G, YP30G v4 Owner's Manual on the Manualsnet website.

Yes, we have the Owner's Manual for Yamaha YP20G as well as other Yamaha manuals. All you need to do is to use our search bar and find the user manual that you are looking for.

The Owner's Manual should include all the details that are needed to use a Yamaha YP20G. Full manuals and user guide PDFs can be downloaded from Manualsnet.com.

The best way to navigate the Yamaha YP20G, YP30G v4 Owner's Manual is by checking the Table of Contents at the top of the page where available. This allows you to navigate a manual by jumping to the section you are looking for.

This Yamaha YP20G, YP30G v4 Owner's Manual consists of sections like Table of Contents, to name a few. For easier navigation, use the Table of Contents in the upper left corner.

You can download Yamaha YP20G, YP30G v4 Owner's Manual free of charge simply by clicking the “download” button in the upper right corner of any manuals page. This feature allows you to download any manual in a couple of seconds and is generally in PDF format. You can also save a manual for later by adding it to your saved documents in the user profile.

To be able to print Yamaha YP20G, YP30G v4 Owner's Manual, simply download the document to your computer. Once downloaded, open the PDF file and print the Yamaha YP20G, YP30G v4 Owner's Manual as you would any other document. This can usually be achieved by clicking on “File” and then “Print” from the menu bar.