Sealey RGH18.V2 Hose Instruction Manual PDF

1 of 2
1 of 2

Summary of Content for Sealey RGH18.V2 Hose Instruction Manual PDF

retractable water hose reel 18mtr 12mm id pvc hose model no: rGh18.v2

thank you for purchasing a sealey product. manufactured to a high standard, this product will, if used according to these instructions, and properly maintained, give you years of trouble free performance.

IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.

1. safety 9 Familiarise yourself with the application and limitations of the hose reel, as well as the specific hazards. warNiNG! disconnect the hose reel from the water supply before changing accessories, servicing or performing any maintenance. 9 maintain thehose reel in good condition (use an authorised service agent). 9 Replace or repair damaged parts. Use recommended parts only. Unauthorised parts may be dangerous and will invalidate the warranty. 9 locate and fix the hose reel in a suitable working area. do Not position the hose in direct sun light, or in areas of extreme heat or

cold. 9 ensure there is adequate lighting. warNiNG! ensure maximum water pressure is not exceeded. 9 Keep extended air hose away from heat, oil and sharp edges. Check hose for wear before each use, and ensure all connections are

secure. 9 maintain correct balance and footing. ensure the floor is not slippery and wear non-slip shoes. 9 Remove ill fitting clothing. Remove ties, watches, rings, and other loose jewellery and contain and/or tie back long hair. 9 Keep children and unauthorised persons away from the working area. 8 do Not operate the hose reel if any parts are damaged or missing as this may cause failure and/or personal injury. 8 do Not exceed the rated capacity of the hose reel. 8 do Not use the hose reel for any purpose other than that for which it is designed. 8 do Not operate the hose reel when you are tired or under the influence of alcohol, drugs or intoxicating medication. 9 When not in use ensure the water supply is turned off and tools disconnected. disconnect from water supply and retract hose into case. warNiNG! DO NOT dismantle the hose reel casing, or attempt to remove the screws and covers on the sides. To do so may result in

damage to the appliance and/or personal injury and will invalidate the warranty. Internal maintenance, which will require the opening of the casing, must only be undertaken by an authorised service agent.

2. iNtroductioN Tough, impact resistant, durable, composite case with wall/ceiling mounting bracket. Fitted with 18mtr high quality PVC hose. Complete with 2mtr leader hose and water gun.

3. specificatioN model no: ..............................................................RGH18.V2 Hose Id: ....................................................................... 12mm length: ..........................................................................18mtr Weight: .......................................................................... 8.5kg

4. iNstallatioN WARNING! DO NOT position the reel in areas of extreme heat or cold.

NOTE: Prolonged exposure to direct and intense sunlight may affect the integrity of the polymers within the moulded components. Avoid, if possible, positioning the reel in direct sunlight. 4.1. mouNtiNG the reel 4.1.1. due to the way the retractable hose operates, the reel should only be mounted in one of two positions shown below. The brackets

supplied will enable you to mount the reel in either position. 4.1.2. ensure the wall, ceiling or other structure, to which the hose reel is to be fixed, is of sound construction and that the securing

points will hold the working strain of the hose when in use. 4.1.3. Using the mounting holes template (cut from box lid), drill appropriate holes for the desired mounting or see diagram below. 4.1.4. When wall mounted the hose exit point should not be more than 2.4 mtrs above floor level. Above this height ceiling mounting is

recommended. See diagrams overleaf. 4.1.5. Fix one bracket to the chosen surface using fixings that are appropriate to the substrate and strong enough to carry the weight

of the reel plus the working strain exerted on it when in use. Position the hose reel onto the first bracket, then proceed to fix the second bracket into place and ensure the reel is secure.

Original Language Version Jack Sealey limited

Refer to instructions

RGH18.V2 | Issue:3 (H,F) 17/07/18

5. operatioN 5.1. Pull out the hose to the required length. A clicking noise will be heard every half revolution of the drum. 5.2. To latch the reel, allow the reel to slowly retract after hearing the 1st, 2nd or 3rd click. 5.3. To unlatch the reel, slowly pull out the hose until the clicking noise stops, then let the hose slowly retract until the hose stopper rests

against the reel mouth. Note: Remove tools from the hose when they are no longer required for use.

WARNING! To prevent injury or damage occurring, DO NOT let go of the hose during rewinding.

6. maiNteNaNcea

warNiNG! Before carrying out routine maintenance or inspection, vent any pressure remaining in the hose. 6.1. The hose reel does not require special maintenance as it is lubricated for life. To ensure reliable operation, clean the hose and

casing regularly. do Not spray or wet the product, but clean with a cloth and warm water. do Not use solvents or detergents, as these may permanently damage the plastic.

6.2. There are no user serviceable parts. All maintenance and repairs which require the case to be opened or dismantled should be carried out by an authorised service agent only.

warNiNG! DO NOT dismantle the hose reel casing, or attempt to remove the screws and covers on the sides. To do so may result in damage to the appliance and/or personal injury and will invalidate the warranty.

6.3. storaGe 6.3.1. Should you wish to store the hose, ensure it is clean and dry. Place the item in a dark, safe, dry, childproof location, where the

temperature will remain reasonably stable. do Not store in a nylon or plastic bag, as this will encourage condensation.

7. troubleshootiNG

RGH18.V2 | Issue:3 (H,F) 17/07/18Original Language Version Jack Sealey limited

1. wall mouNtiNG 2. ceiliNG mouNtiNG

problem possible cause solutioN Hose will not retract: Hose bunching within reel.

Spring tension too tight. Replacement hose too heavy.

Pull hose out of reel and guide back in. Have spring tension adjusted by authorised service agent. Have correct hose fitted by authorised service agent.

Reel will not latch: The hose has been pulled past the latching teeth. Broken latching pawl or pawl spring.

Allow reel to retract slowly after hearing 1st, 2nd or 3rd click. Have new latching pawl or pawl spring fitted by authorised service agent.

Reel leaks: damaged hose. Have new hose fitted by authorised service agent.

sealey Group, Kempson way, suffolk business park, bury st edmunds, suffolk. ip32 7ar 01284 757500 01284 703534 sales@sealey.co.uk www.sealey.co.uk

Note: It is our policy to continually improve products and as such we reserve the right to alter data, specifications and component parts without prior notice. important: no liability is accepted for incorrect use of this product. warranty: Guarantee is 12 months from purchase date, proof of which is required for any claim.

eNviroNmeNt protectioN Recycle unwanted materials instead of disposing of them as waste. All tools, accessories and packaging should be sorted, taken to a recycling centre and disposed of in a manner which is compatible with the environment. When the product

Manualsnet FAQs

If you want to find out how the RGH18.V2 Sealey works, you can view and download the Sealey RGH18.V2 Hose Instruction Manual on the Manualsnet website.

Yes, we have the Instruction Manual for Sealey RGH18.V2 as well as other Sealey manuals. All you need to do is to use our search bar and find the user manual that you are looking for.

The Instruction Manual should include all the details that are needed to use a Sealey RGH18.V2. Full manuals and user guide PDFs can be downloaded from Manualsnet.com.

The best way to navigate the Sealey RGH18.V2 Hose Instruction Manual is by checking the Table of Contents at the top of the page where available. This allows you to navigate a manual by jumping to the section you are looking for.

This Sealey RGH18.V2 Hose Instruction Manual consists of sections like Table of Contents, to name a few. For easier navigation, use the Table of Contents in the upper left corner.

You can download Sealey RGH18.V2 Hose Instruction Manual free of charge simply by clicking the “download” button in the upper right corner of any manuals page. This feature allows you to download any manual in a couple of seconds and is generally in PDF format. You can also save a manual for later by adding it to your saved documents in the user profile.

To be able to print Sealey RGH18.V2 Hose Instruction Manual, simply download the document to your computer. Once downloaded, open the PDF file and print the Sealey RGH18.V2 Hose Instruction Manual as you would any other document. This can usually be achieved by clicking on “File” and then “Print” from the menu bar.