Contents

Rangemaster Integrated RTFZ18 White Chrome User Guide PDF

1 of 32
1 of 32

Summary of Content for Rangemaster Integrated RTFZ18 White Chrome User Guide PDF

Integrated Freezer

User Guide &

Installation & Service Instructions

U110832-04

1. Before You Start 1 Safety 1

Electrical Safety 2

CE Declaration of conformity 3

Disposal of your old appliance 3

Packaging and the Environment 3

2. About Your Freezer 4 Using the appliance 5

3. Using the Control Panel 6 Operating your Freezer 6

Accessories 7

4. Food Storage Tips 8 Food storage 8

Tips on Freezing Food 9

5. Food Storage Table 10

6. Cleaning and Maintenance 12

7. Troubleshooting 14

8. Installation 16 Installation warnings 16

Positioning Your Appliance 17

Electrical Supply Connection 18

9. Circuit diagram 23

10. Technical Data 24

11. Warranty/After Sales Service 26

Due to our policy of continual improvement, we reserve the right to change specifications without prior notice.

Contents

1

Make sure that the electrical supply to your plug socket is correct for this appliance the required information is on the data badge of the appliance.

Once the appliance is installed, cleaned and dry, it is ready to be plugged in and switched on.

Safety

n The data badge is located inside the appliance (refrigeration compartment).

n WARNING: Use potable (drinking) water with this appliance.

n WARNING: Keep this appliance clear of any obstruction.

n DO NOT damage the refrigerant circuit. If it does become damaged, do not use the appliance.

n WARNING: DO NOT use mechanical devices (such as hairdryers) to defrost this appliance.

n If your appliance uses R600a as a refrigerant (this information will be provided on the label of the cooler) you should take care during transportation and installation to prevent the cooler elements from being damaged. R600a is an environmentally friendly and natural gas, but it is explosive. In the event of a leak due to damage of the cooler elements, move your appliance away from open flames or heat sources and ventilate the room where the appliance is located for a few minutes.

When replacing old appliances, make sure that you have disabled any locking mechanisms before disposal it may even be best to remove the appliance door completely to prevent children from becoming trapped inside the appliance.

The appliance must be connected to the power supply safely. Loose connections, broken plugs and bare wires are a safety hazard. Make sure that all connections are sound.

Before undertaking any routine maintenance or minor repairs, disconnect the appliance from the electrical supply.

DO NOT touch cold surfaces of the appliance while it is in use as this will cause hands to stick to them leading to freezer burns.

When moving the appliance take care not to damage the leads, pipes or condenser unit. Should these parts become damaged, contact a qualified service engineer.

Effervescent liquids (fizzy drinks) should never be frozen. These liquids expand during freezing and this may lead to the bottles/containers shattering or exploding.

Icon Type Meaning

WARNING Serious injury or death risk

Dangerous voltage risk

FIRE Fire risk

CAUTION Injury or property damage risk

IMPORTANT Operating the system correctly

RISK OF ELECTRIC SHOCK

1. Before You Start

Thank you for buying this appliance. We hope that it provides a stylish yet practical solution to your cooling needs. We hope that this handbook supplies you with all the information you require. If there is anything you are unsure of please contact us (see Warranty section for Customer Cares details).

n WARNING: This appliance must be earthed.

n Please leave the appliance to stand for at least six hours. This will allow the cooling system to settle following transportation.

n Always make sure a qualified person installs this appliance.

n This appliance is designed for domestic use only. Using it for any other purpose could invalidate any warranty or liability claim.

n Children aged from 3 to 8 years are allowed to load and unload refrigerating appliances. Children are not expected to perform cleaning or user maintenance of the appliance, very young children (0-3 years old) are not expected to use appliances, young children (3-8 years old) are not expected to use appliances safely unless continuous supervision is given, older children (8-14 years old) and vulnerable people can use appliances safely after they have been given appropriate supervision or instruction concerning use of the appliance. Very vulnerable people are not expected to use appliances safely unless continuous supervision is given.

Before you plug the appliance into the mains, clean the inside of the appliance using warm water and bicarbonate of soda, then dry thoroughly.

Check that no parts of the appliance are damaged, especially parts of the cooling system, pipes or leads. If damage has occurred, DO NOT install the appliance; you should contact a qualified service engineer or return the appliance to its place of purchase.

If the accessories inside the appliance have been disturbed during transit, reposition them in accordance with the instructions.

2

Foods that are intended to be defrosted or cooked first, such as breads or meats, must not be eaten in their frozen state.

If food looks or smells strange, do not attempt to eat it. If in doubt throw it away. Spoiled food can be harmful to your health.

Never use sharp, metal implements to scrape ice off the surface of this appliance. Only use implements, which are fit for this purpose (such as plastic scrapers) and use carefully to avoid damaging the lining of the appliance.

The cooling system contains refrigerant and oils, all of which are harmful to health if leaked. Should leakage occur, disconnect the appliance and ventilate the room it is installed in. Take care to ensure that you do not get any coolant near to, or in, your eyes. Contact a service engineer or arrange to have the appliance removed. DO NOT use the appliance under any circumstances.

n WARNING: Keep ventilation openings, in the appliance enclosure or in the built-in structure, clear of obstruction.

n WARNING: DO NOT use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.

n WARNING: DO NOT use electrical appliances inside the food storage compartments of the appliance, unless they are of the type recommended by the manufacturer.

n WARNING: DO NOT damage the refrigerant circuit.

n WARNING: In order to avoid any hazards resulting from the instability of the appliance, it must be fixed in accordance with the following instructions: If your appliance uses R600a as a refrigerant (this information will be provided on the label of the cooler) you should take care during transportation and installation to prevent the cooler elements from being damaged. R600a is an environmentally friendly and natural gas, but it is explosive. In the event of a leak due to damage of the cooler elements, move your appliance away from open flames or heat sources and ventilate the room where the appliance is located for a few minutes.

While carrying and positioning the appliance, do not damage the cooler gas circuit.

DO NOT store explosive substances such as aerosol cans with a flammable propellant in this appliance.

This appliance is intended to be used in household and domestic applications only.

If the socket does not match the appliance plug, it must be replaced by the manufacturer, a service agent or similarly qualified persons in order to avoid a hazard.

A specially grounded plug has been connected to the power cable of your appliance. This plug should be used with a specially grounded socket of 13 amperes. If there is no

such socket in your house, please have one installed by an authorised electrician.

This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved.

Children shall not play with the appliance. Cleaning and user maintenance shall not be made by children without supervision.

If the supply cord is damaged, it must be replaced by the manufacturer, an authorised service agent or similar qualified persons, in order to avoid a hazard.

This appliance is not intended for use at altitudes exceeding 2000 m.

Electrical Safety

n WARNING: When positioning the appliance, ensure the supply cord is not trapped or damaged.

n WARNING: DO NOT locate multiple portable socket- outlets or portable power supplies at the rear of the appliance.

n DO NOT use plug adapter.

ArtNo.000-0001 Warning triangle WARNING; Risk of fire / flammable materials

The plug must be accessible after installation.

The operating voltage for your appliance is 220-240 V at 50Hz.

Connections to the mains supply should be in accordance with local regulations.

Insert the plug into a socket with an efficient ground connection. If the socket has no ground contact or the plug does not match, we recommend you consult a qualified electrician for assistance.

The appliance must be connected with a properly installed fused socket. The power supply (AC) and voltage at the operating point must match with the details on the name plate of the appliance (the name plate is located on the inside left of the appliance).

The appliance must be plugged into an earthed socket.

The plug MUST be accessible after the appliance has been positioned.

The appliance is supplied with a standard three-pin plug, of which the one for grounding should never be removed.

Hold the plug, not the electrical cable, when unplugging the appliance.

Make sure that the appliance does not trap the electric cable.

DO NOT step on the cable.

3

Avoid damage to the electric cable when moving the appliance.

CE Declaration of conformity We declare that our products meet the applicable

European Directives, Decisions and Regulations and the requirements listed in the standards referenced.

Disposal of your old appliance

ArtNo.000-0019 Do not bin logo

The symbol on the product or on its packaging indicates that this product may not be treated as household waste. Instead it shall be handed over to the applicable collection point for the recycling of electrical and electronic equipment. By ensuring this product is disposed of correctly, you

will help prevent potential negative consequences for the environment and human health, which could otherwise be caused by inappropriate waste handling of this product. For more detailed information about recycling of this product, please contact your local city office, your household waste disposal service or the shop where you purchased the product.

Packaging and the Environment

ArtNo.000-0019 Do not bin logo

Packaging materials protect your machine from damage that may occur during transportation. The packaging materials are environmentally friendly as they are recyclable. The use of recycled material reduces raw material consumption and

therefore decreases waste production.

Notes:

Please read the instruction manual carefully before installing and using your appliance. We are not responsible for the damage occurred due to misuse.

Follow all instructions on your appliance and instruction manual, and keep this manual in a safe place to resolve the problems that may occur in the future.

This appliance is produced to be used in homes and it can only be used in domestic environments and for the specified purposes. It is not suitable for commercial or common use. Such use will cause the guarantee of the appliance to be cancelled and our company will not be responsible for the losses to be occurred.

This appliance is produced to be used in houses and it is only suitable for cooling / storing foods. It is not suitable for commercial or common use and/or for storing substances except for food. Our company is not responsible for the losses to be occurred in the contrary case.

To avoid contamination of food, please respect the following instructions:

Opening the door for long periods can cause a significant increase of the temperature in the compartments of the appliance.

Clean regularly surfaces that can come in contact with food and accessible drainage systems

Store raw meat and fish in suitable containers in the refrigerator, so that it is not in contact with or drip onto other food.

Two-star frozen-food compartments are suitable for storing pre-frozen food, storing or making ice cream and making ice cubes.

One-, two- and three-star compartments are not suitable for the freezing of fresh food.

If the refrigerating appliance is left empty for long periods, switch off, defrost, clean, dry, and leave the door open to prevent mould developing within the appliance.

4

The freezer is shown in Fig. 2.1 and has the following features:

1. Control panel

2. Freezer upper room flap

3. Freezer bottom room flap / Freezer compartment drawer

4. Freezer compartment drawers

5. Ice tray

6. Freezer LED strip

4

3

2

1

5

6

2. About Your Freezer

Fig. 2.1

5

Using the appliance Information on No-Frost Technology (Fig. 2.2)

No-frost freezers have a different operating system to static freezers. In normal (static) freezers, the humidity entering the freezers due to opening the door and the humidity inherent in the food causes ice to form in the freezer compartment.

To remove the frost and ice from the freezer compartment, it is required to periodically switch the fridge off and place frozen food in a separate cooled container.

The situation is completely different in Nofrost fridges. A built-in fan blows dry and cold air evenly into the cooler and freezer compartments. The cold air disperses uniformly between the shelves, ensuring all your food is cooled evenly, thus preventing humidity and icing to occur.

Therefore, your No-frost fridge allows ease of use, in addition to its huge capacity and stylish appearance.

In the refrigerator compartment, there will be nearly same configuration with freezer compartment. Air, that is emitted with the fan, located at the top of refrigerator compartment, is cooled while passing through the gap behind the air duct. At the same time, air is blown out through the holes on the air duct so that cooling process is successfully completed in the refrigerator compartment.

Holes in the air duct are designed such that the air distribution becomes homogenous in this compartment. As there is no air passage between freezer and refrigerator compartment, there will be no odor mixing.

As a result of these, your fridge with new generation cooling technology, gives you, ease of use beside the huge volume and esthetic appearance.

Fig. 2.2

6

-16 -18 -20 -22 -24

1 2 3 4

Fig. 3.1

Using the Control Panel

1. Freezer temperature set button

2. Super freeze symbol (Super freeze LED)

3. Alarm symbol (Alarm LED)

4. Freezer adjusted temperature indicator

Operating your Freezer Freezer Temperature Set Button

This button allows setting temperature of the freezer. In order to set values for freezer, press button 1 (Fig. 3.1).

Super Freeze Mode

When would it be used?

To freeze large quantities of food.

To freeze fast food.

To freeze food quickly.

To store seasonal food for a long time.

To use the super freeze mode press the temperature set button until super freezer light comes on (Fig. 3.2). To cancel press the temperature set button the setting will be restored to -18C.

Do not exceed the maximum load for freezing which is given as 15 kg / 24-hours (see data badge for details).

For optimal appliance performance in maximum freezer capacity, set the appliance to active super freeze mode 24 hours before you put the fresh food into the freezer.

NOTE: The super freezing mode will be cancelled automatically after 24 hours or when the freezer sensor temperature falls below -32 C.

3. Using the Control Panel

-16 -18 -20 -22 -24

Fig. 3.2

7

Freezer Temperature Settings

The initial temperature of the setting display is -18C.

To change the temperature press freezer setting button once. Every time you press the button, the setting temperature will decrease.

Recommended Temperature Values for Freezer (Table 3.1)

Temperature Settings Warnings

It is not recommended that you operate your freezer in environments colder than 10C in terms of its efficiency.

Do not start another adjustment before completing one adjustment.

Temperature adjustments should be made according to the frequency of door openings, the quantity of food kept inside the freezer and the ambient temperature in the location of your freezer.

In order to allow your appliance to reach the operating temperature after being connected to mains, do not open the door frequently or place large quantities of food in the freezer. Please note that, depending on the ambient temperature, it may take 24 hours for your freezer to reach the operating temperature.

If the appliance is switched off or unplugged, wait at least 5 minutes before plugging the appliance in or restarting it this will prevent damage to the compressor.

Your appliance is designed to operate in the ambient temperature (T/SN = 10C - 43C) intervals stated in the standards. We do not recommend operating your appliance out of the stated temperature limits in terms of cooling effectiveness.

Accessories Ice Tray (Fig. 3.4)

Fill the ice tray with water and place in the freezer compartment (Fig. 3.3).

After the water has completely frozen, you can twist the tray to remove the ice cube (Fig. 3.3) s.

Do not bend the icetray to remove the ice (Fig. 3.4)

n Do not fill the icebox with water in order to make ice. It will break.

When to adjust Inner Temperature For minimum freezing capacity -16C, -17C

In normal usage -18C, -19C,

-20C, -21C

For maximum freezing capacity -22C, -23C, -24C

Table 3.1

Fig. 3.3

Fig. 3.4

8

Food storage Freezer Compartment

The freezer is used for storing frozen food, freezing fresh food, and making ice cubes.

To freeze fresh food, ensure that as much of the surface of the food as possible is in contact with the cooling surface.

Do not store fresh food next to frozen food as it can thaw the frozen food.

Before freezing fresh food, divide it into portions that can be consumed in one sitting.

Consume thawed frozen food within a short period of time after defrosting

Never place warm food in the freezer compartment as it will thaw the frozen food.

Always follow the manufacturers instructions on food packaging when storing frozen food. If no information is provided food, should not be stored for more than 3 months from the date of purchase.

When purchasing frozen food, make sure that it has been stored under appropriate conditions and that the packaging is not damaged.

Frozen food should be transported in appropriate containers and placed in the freezer as soon as possible.

Do not purchase frozen food if the packaging shows signs of humidity and abnormal swelling. It is probable that it has been stored at an unsuitable temperature and that the contents have deteriorated.

The storage life of frozen food depends on the room temperature, the thermostat setting, how often the door is opened, the type of food, and the length of time required to transport the product from the shop to your home. Always follow the instructions printed on the packaging and never exceed the maximum storage life indicated.

The maximum amount of fresh food (in kg) that can be frozen in 24 hours is indicated on the appliance label.

To use the maximum capacity of the freezer compartment, use the glass shelves for the upper and middle section, and use the lower basket for the bottom section.

To use the maximum load capacity of your freezer, and to store large quantities of food, remove all drawers except the bottom one. Large items can be stored directly on the shelves.

To use the maximum freezing capacity of your freezer move the frozen food in the upper basket to other baskets and activate Super freeze mode. Super freeze mode will be deactivated automatically after 24 hours. Place the food you want to freeze to the upper basket of the freezer without exceeding the freezing capacity of your freezer. Then reactivate the Super freeze mode. You can put your food next to other frozen food after it is completely frozen (minimum 24 hours after Super freeze mode is activated for the 2nd time).

To freeze a small amount of food (up to 3 kg) in your freezer, place your food without touching already frozen food and activate Super freeze mode. You can put your food next to other frozen food after it is completely frozen (after minimum 24 hours).

n Attention. To save energy, when freezing small amounts of food, reset the temperature to the previous value as soon as the food is completely frozen.

NOTE: If you attempt to open the freezer door immediately after closing it, you will find that it will not open easily. This is normal. Once equilibrium has been reached, the door will open easily.

4. Food Storage Tips

9

Tips on Freezing Food As with storing fresh foods, suitable packaging, correct

temperature and food hygiene will enhance the quality of the food you are freezing.

Avoid putting hot foods into the freezer. First let them cool until they reach room temperature.

Make sure that all foods for freezing are of a high quality, and suitable for freezing.

Use packaging material that is odourless and airproof (such as plastic bags) to store food in so different foods can be mixed without affecting the quality. Make sure that it is airtight. Leaking packaging will dehydrate the products and lead to loss of beneficial vitamins.

Keep the surface of the packaging dry this keeps the packs from freezing together.

Mark packages with the kind of food contained and the date of storage.

Food needs to be frozen quickly, so it is best to freeze small portions whenever possible and ensure that they are as cold as possible before storage. The recommended maximum weight for each portion is 2.5 kg.

Keep food which is fresh away from food which is already frozen, if you need to freeze fresh food every day, make sure that it is in small portions to prevent this.

Do not exceed the maximum load for freezing which is given as 15 kg / 24-hours (see data badge for details).

Write the expiry date and food names on the outside of the packaging so you can be assured of the food type and when it is safe to eat.

Take food from the freezer to defrost when needed. Defrosted food cannot be refrozen unless it is cooked.

Do not put too much fresh food into the freezer at once. This could go beyond the freezers cooling capacity (see Technical Data).

When storing commercially frozen foods, please follow these guidelines:

Always follow manufacturers guidelines for the length of time you should store food for. Do not exceed these guidelines!

Try to keep the length of time between purchase and storage as short as possible to preserve food quality.

Buy frozen foods, which have been stored at a temperature of 18 C or below.

Avoid buying food which has ice or frost on the packaging This indicates that the products might have been partially defrosted and refrozen at some point temperature rises affect the quality of food.

Should there be a power cut, or the freezer / refrigeration appliance fail for any length of time you may need to remove food from the freezer and store in a cold, hygienic place (i.e. garage or out house area) until the power is restored, or the appliance is repaired.

To prevent undue temperature rises you should wrap the foods in layers of insulating material, such as newspaper, to help to maintain their temperature. It is also important that any food affected by this situation should be either consumed or cooked and refrozen (where suitable) soon afterwards in order to prevent health risks.

10

Meat and fish Preparation Maximum storage time (months) Steak Wrap in foil 6 - 8

Lamb meat Wrap in foil 6 - 8

Veal roast Wrap in foil 6 - 8

Veal cubes In small pieces 6 - 8

Lamb cubes In pieces 4 - 8

Minced meat In packaging without using spices 1 - 3

Giblets (pieces) In pieces 1 - 3

Bologna sausage/salami Should be kept packaged even if it has a membrane

Chicken and turkey Wrap in foil 4 - 6

Goose and duck Wrap in foil 4 - 6

Deer, rabbit, wild boar In 2.5 kg portions or as fillets 6 - 8

Freshwater fish (Salmon, Carp, Crane, Catfish) After cleaning the bowels and scales of the fish, wash and dry it. If necessary, remove the tail and

head.

2

Lean fish (Bass, Turbot, Flounder) 4

Fatty fishes (Tuna, Mackarel, Bluefish, Anchovy) 2 - 4

Shellfish Clean and in a bag 4 - 6

Caviar In its packaging, or in an aluminium or plastic container 2 - 3

Snails In salty water, or in an aluminium or plastic container 3

NOTE: Thawed frozen meat should be cooked as fresh meat. If the meat is not cooked after defrosting, it must not be re-frozen.

Vegetables and Fruits Preparation Maximum storage time (months) String beans and beans Wash, cut into small pieces and boil in water 10 - 13

Beans Hull, wash and boil in water 12

Cabbage Clean and boil in water 6 - 8

Carrot Clean, cut into slices and boil in water 12

Pepper Cut the stem, cut into two pieces, remove the core and boil in water 8 - 10

Spinach Wash and boil in water 6 - 9

Cauliflower Remove the leaves, cut the heart into pieces and leave it in water with a little lemon juice for a while 10 - 12

Eggplant (Aubergine) Cut into pieces of 2cm after washing 10 - 12

Corn Clean and pack with its stem or as sweet corn 12

Apple and pear Peel and slice 8 - 10

Apricot and Peach Cut into two pieces and remove the stone 4 - 6

Strawberry and Blackberry Wash and hull 8 - 12

Cooked fruits Add 10 % of sugar to the container 12

Plum, cherry, sourberry Wash and hull the stems 8 - 12

5. Food Storage Table All storage times given in the table below are intended to be used as a guide only. Storage times of fruits and vegetables depend on the quality of the food. Individual cases may vary.

Packaged fruits and vegetables are consumed until expiration.

n Important

The taste of some spices found in cooked dishes (anise, basilica, watercress, vinegar, assorted spices, ginger, garlic, onion, mustard, thyme, marjoram, black pepper, etc.) changes and they assume a strong taste when they are stored for a long period of time. Therefore, add small amounts of spices to food to be frozen, or the desired spice should be added after the food has thawed

The storage time of food is dependent on the type of oil used. Suitable oils are margarine, calf fat, olive oil and butter. Unsuitable oils are peanut oil and pig fat.

Food in liquid form should be frozen in plastic cups/ tupperware and other food should be frozen in plastic folios or bags.

The table below is a quick guide to show you the most efficient way to store the major food groups in your freezer compartment.

DocNo.031-0004 - Cooking table - electric & fan single cavity

11

Maximum storage time (months)

Thawing time at room temperature (hours) Thawing time in oven (minutes)

Bread 4 - 6 2 - 3 4-5 (220-225 C)

Biscuits 3 - 6 1 - 1.5 5-8 (190-200 C)

Pastry 1 - 3 2 - 3 5-10 (200-225 C)

Pie 1 - 1.5 3 - 4 5-8 (190-200 C)

Phyllo dough 2 - 3 1 - 1.5 5-8 (190-200 C)

Pizza 2 - 3 2 - 4 15-20 (200 C)

Dairy products Preparation Maximum storage time (months) Storage conditions

Packet (Homogenized) Milk In its own packet 2 - 3 Pure Milk in its own packet

Cheese - excluding white cheese In slices 6 - 8 Original packaging may be used for short-

term storage. Keep wrapped in foil for longer periods.

Butter, margarine In its packaging

12

6. Cleaning and Maintenance

Cleaning

n Disconnect the appliance from the power supply before cleaning.

n Do not wash your appliance by pouring water on it.

n DO NOT use harsh abrasives, or aggressive cleaners as these can damage the interior of the appliance.

n The freezer is heavy. When moving the freezer be careful to protect the floor. Keep the freezer vertical and do not tilt the freezer this prevents damage to the floor.

n DO NOT spray or rinse the freezer with water or other liquids. This could harm the electrical parts.

n Use a dry cloth when cleaning near the electrical parts (such as the light bulb or switch).

n DO NOT clean the freezer with a stiff or wire brush.

n DO NOT use an organic solvent such as detergent, petrol, lacquer, thinners, acetone or acid.

n To prevent your skin sticking to cold steel parts, make sure your hands are not wet when touching the parts.

n DO NOT use HOT water to clean the glass shelves, as they may break or crack.

Empty the appliance of food and remove the shelves.

Clean the interior using warm water and bicarbonate of soda with a soft cloth. Make sure that the interior is then dried carefully with a suitable cloth.

After washing, rinse with clean water and dry carefully. When you have finished cleaning, reconnect the plug to the mains supply with dry hands.

Shelves and other accessories (plastic and glass parts) can be cleaned in the sink using liquid dishwashing liquid and warm water. Make sure all soap is rinsed off and all parts are dry before replacing them inside the appliance.

Always keep the door seals clean.

Make sure that no water enters the lamp housing and other electrical components.

The appliance should be cleaned regularly using a solution of bicarbonate of soda and lukewarm water.

Clean the accessories separately by hand with soap and water. Do not wash accessories in a dish washer.

Clean the condenser with a brush at least twice a year. This will help you to save on energy costs and increase productivity.

Clean regularly surfaces that can come in contact with food and accessible drainage systems.

Store raw meat and fish in suitable containers to avoid decontaminating other foods.

Two-star frozen-food compartments are suitable for storing pre-frozen food, storing or making ice cream and making ice cubes.

One-, two- and three-star compartments are not suitable for the freezing of fresh food.

13

Defrosting the freezer (Fig. 6.1)

Your appliance performs automatic defrosting. The water formed as a result of defrosting passes through the water collection spout, flows into the vaporisation container behind your appliance and evaporates there.

Make sure you have disconnected the plug of your appliance before cleaning the vaporisation container.

Remove the vaporisation container from its position by removing the screws as indicated. Clean it with soapy water at specific time intervals. This will prevent odours from forming.

Replacing LED Lighting (Fig. 6.2) (Selected models)

Please refer to the Warranty chapter as this should be changed by authorised personnel only.

The LED interior lights come on when the door is opened. The performance of the light is not affected by any of the appliances other settings.

Note: The numbers and location of the LED strips may change according to the model.

Evaporator Tray

LED strip

Fig. 6.1

Fig. 6.2

14

7. Troubleshooting Before calling for service, please first read the following table: this could save you time and money.

Error type Meaning Why What to do Failure Warning There is/are some part(s) out of order or there

is a failure in the cooling process.

The product is plugged for the first time or a long-time power interruption for 1 hour.

Check the door is open or not and check if the product working 1 hour. If the door is not open and the product had worked 1 hour, call service for assistance as soon as possible.

If you are experiencing a problem with your appliance, please check the following before contacing the after-sales service.

Only a qualified service engineer should service the appliance and only approved spare parts should be used.

n Isolate the electricity supply before carrying out any maintenance.

Your appliance does not operate

Check if:

There is power

The plug is connected to the socket correctly

The socket fuse or the mains fuse has blown

The socket is faulty. To check this, plug another working appliance into the same socket.

Your appliance is performing poorly

Check if:

The appliance is overloaded

The doors are closed properly

There is any dust on the condenser (Fig. 7.1)

There is an adequate distance between the appliance and surrounding walls. Please refer to Installation chapter.

Your appliance is operating noisily

The following noises can be heard during normal operation of the appliance.

Cracking (ice cracking) noise occurs: During automatic defrosting. When the appliance is cooled or warmed (due to expansion of appliance material).

Motor noise: Indicates the compressor is operating normally. The compressor may cause more noise for a short time when it is first activated.

Bubbling noise and splashing occurs: Due to the flow of the refrigerant in the tubes of the system.

Air blowing noise occurs: During normal operation of the system due to the circulation of air.

Condenser

Fig. 7.1

15

The edges of the appliance in contact with the door joint are warm

Especially during summer (warm seasons), the surfaces in contact with the door joint may become warmer during the operation of the compressor, this is normal.

There is a build-up of humidity inside the appliance

Check if:

All food is packed properly. Containers must be dry before being placed in the freezer.

The freezer doors are opened frequently. Humidity of the room will enter the freezer each time the doors are opened. Humidity increases faster if the doors are opened frequently, especially if the humidity of the room is high.

There is a build-up of water droplets on the rear wall. This is normal after automatic defrosting (in Static Models).

The doors are not opening or closing properly

Check if:

There is food or packaging preventing the door from closing

The door compartments, shelves and drawers are placed properly

The door gaskets are broken or torn

Your freezer is level.

Recommendations

To stop the appliance completely, unplug from main socket (for cleaning and when the door is left open)

n Important:

In the case of a power failure, or if the appliance is unplugged and plugged in again, the gas in the cooling system of your refrigerator will destabilise, causing the compressor protective thermal element to open.

Your freezer will start to operate normally after 5 minutes.

If the appliance will not be used for a long period of time (such as during holidays), disconnect the plug. Defrost and clean the refrigerator, leaving the door open to prevent the formation of mildew and odour.

If the problem persists after you have followed all the instructions above, please consult the nearest Authorised

Service Centre.

This appliance is designed for domestic use and for the stated purposes only. It is not suitable for commercial or common use. If the consumer uses the appliance in a way that does not comply with these instructions, we emphasise that the manufacturer and the dealer will not be responsible for any repair or failure within the guarantee period.

Tips for saving energy 1. Install the appliance in a cool, well ventilated room, but

not in direct sunlight and not near a heat source (such as a radiator or oven) otherwise an insulating plate should be used.

2. Allow warm food and drinks to cool before placing them inside the appliance.

3. Drinks or other liquids should be covered when inside the appliance. If left uncovered, the humidity inside the appliance will increase, therefore the appliance uses more energy. Keeping drinks and other liquids covered helps preserve their smell and taste.

4. Avoid keeping the doors open for long periods and opening the doors too frequently as warm air will enter the appliance and cause the compressor to switch on unnecessarily often.

5. The door gasket must be clean and pliable. Replace gaskets if worn.

16

Installation warnings Before using your appliance for the first time, please pay attention to the following points:

Your appliance may have an odour when it is operated for the first time. This is normal and the odour will fade when your appliance starts to cool.

Before connecting your appliance, ensure that the information on the data plate (voltage and connected load) matches that of the mains electricity supply. If in doubt, consult a qualified electrician.

We do not accept responsibility for any damages that occur due to ungrounded usage.

Place your appliance where it will not be exposed to direct sunlight.

Your appliance must never be used outdoors or exposed to rain.

Your appliance must be at least 50 cm away from stoves, gas ovens and heater cores, and at least 5 cm away from electrical ovens.

If your appliance is placed next to a deep freezer, there must be at least 2 cm between them to prevent humidity forming on the outer surface.

Do not cover the body or top of appliance with lace. This will affect the performance of your appliance.

Do not place anything on top of your appliance.

Do not place heavy items on the appliance.

Clean the appliance thoroughly before use (see Cleaning and Maintenance).

The installation procedure into a kitchen unit is given in the installation manual. This product is intended to be used in the kitchen.

Before using your appliance, wipe all parts with a solution of warm water and a teaspoon of sodium bicarbonate. Then, rinse with clean water and dry. Return all parts to the appliance after cleaning.

8. Installation

17

Positioning Your Appliance

n The refrigerator must be carried by at least 4 people.

The original packaging and foam may be kept for re- transportation (optional).

Fasten your appliance with thick packaging, bands or strong cords and follow the instructions for transportation given on the package.

Remove all movable parts (shelves, accessories, vegetable bins, etc.) or fix them into the appliance against shocks using bands during re-positioning and transportation.

An ambient sensor, main board and hinge covers are available on your refrigerator. During cleaning, make sure no fluid enters this area.

Choosing the Right Location

Avoid exposing the appliance to direct sunlight, and sources of heat (such as radiators, heaters or cookers).

If this appliance is situated in a cold environment (such as a shed, outhouse or garage) it will affect its performance. You may find that the performance of the appliance is not consistent and this may damage foods. A consistent ambient temperature of 10 C or above is recommended.

Refrigerator should be placed against a wall with a free distance not exceeding 75 mm.

18

Electrical Supply Connection Connect the appliance to the electrical supply (220-240 V ~ 50 Hz) with the plug and lead, which are fitted.

Connections to the mains supply should be in accordance with local regulations.

n DO NOT use plug adapter.

n The appliance must be plugged into an earthed socket.

n Always make sure that the plug is accessible after the appliance has been positioned.

If the electrical cable is damaged or worn, turn off the refrigerator and consult an authorised agent for replacement.

The appliance is supplied with a standard 13 amp 3-pin mains plug fitted with a 13-amp fuse. Should the fuse require replacement, it must be replaced with a fuse rated at 13 amp and approved to BS1362.

If the mains plug which is fitted is unsuitable for the socket outlet in your home or is removed for any other reason, please contact an approved electrician.

During Usage

Do not connect your appliance to the mains electricity supply using an extension lead.

Do not use damaged, torn or old plugs.

Do not pull, bend or damage the cord.

This appliance is designed for use by adults. Do not allow children to play with the appliance or hang off the door.

Never touch the power cord/plug with wet hands. This may cause a short circuit or electric shock.

Do not place explosive or flammable material in your appliance. Place drinks with high alcohol content vertically in the appliance compartment and make sure their tops are tightly closed.

When removing ice from the icemaking compartment, do not touch it. Ice may cause frost burns and/or cuts.

Do not touch frozen goods with wet hands. Do not eat ice-cream or ice cubes immediately after they are removed from the ice-making compartment.

Do not re-freeze thawed frozen food. This may cause health issues such as food poisoning.

If your old appliance or freezer has a lock, break or remove the lock before discarding it, because children may get trapped inside it and may cause an accident.

Old appliances and freezers contain isolation material and refrigerant with CFC. Therefore, take care not to harm environment when you are discarding your old appliances.

19

1

2

3 4 5

4

pH2pH2

4

1a (1 x)

2 (1 x)

(2 x)

7 (1 x)

6 (4 x)

4 (2 x)

5 (25 x)

(1 x) 1b

8 (4 x) 9

4(4 x) 10

540 mm

A

545 mm

min. 200 cm

B

m m

0012.xa m

560-570mm

75mm

75mm

550mm

min

560 mm

200cm

90

=

90

200cm

200cm

min.75 mm

min.75 mm

2mm 2mm

3

(1 x) 3

(recommended)

(Recommended)

1b1a

20

B

2

8

1

(2 x) 8 C

D 1 2 90E

7

4

A

7 (1 x)

(1 x)

4 (2 x)

1

7

4

2

1a

1a

21

X

I

3

G

5m m

5 mm

2 1

H

X

X

5 (8x)

2

5

F

2 2

3 3 1

5

3

5

22

L1L L2

L4L3

x 3

5

1

5 (5 x)

K

3 x

5

2

1

2

3 (1 x)

1 2

3

4

9mm

9

6 5

10

5

2

5 (12 x)

6 (4 x)(4 x)

10 (4 x)

2 (1 x)

click

M

9

23

9. Circuit diagram ArtNo.095-0003 - Circuit diagram - 90 induction

1 2 3 4 5 6 7 8 9 10 11 12

20BD53 DISPLAY

20BD52 MAINBOARD

FREEZER SENSOR

SERPANTIN SENSOR

DOOR SWITCH LED

CN8

D E

FR O

S T

R E

S IS

TA N

C E

THERMAL FUSE

L E N

TR AY

R

E S

IS TA

N C

E

D R

A IN

R

E S

IS TA

N C

E

FAN

CN2 CN2

CN3

1 2 3 4 5 6 7 81 2 3 4

RAN CAPASITOR

COMPRESSOR

W H

IT E

Y E

LL O

W

1 2 3 4 5

B R

O W

N

B LA

C K

B LU

E

1 2 3

R E

D

G R

E Y

P IN

K W

H IT

E

W H

IT E

B R

O W

N

B R

O W

N

R E

D

O R

A N

G E

Y E

LL O

W

POSITIVE TEMPERATURE COEFFICIENT

OVERLOAD PROTECTOR

24

10. Technical Data INSTALLER: Please leave these instructions with the user.

DATA BADGE LOCATION: Left-hand side of the refrigerator compartment.

COUNTRY OF DESTINATION: GB, IE.

Dimensions

545 540

All dimensions in mm

1770

Door Clearances This illustration is prepared according to 20mm furniture thickness. The hinge can open up to 110 and the handle on the furniture is a sample.

187

Max. 110

62.5

220

DocNo.600-0008 - Technical data - DxD 910

25

Ratings

Brand RANGEMASTER

Model identification RTFZ18/INT

Product category 8 (Freezer)

Mass kg 62

Number of cavities 1

Energy class A+

Annual energy consumption* 297 kWh

Total gross volume 221 litres

Total net volume 197 litres

Refrigerator gross volume - litres

Refrigerator net volume - litres

Chiller compartment net volume - litres

Freezer gross volume 221 litres

Freezer net volume 197 litres

Star rating ****

Refrigeration system NO FROST

Temperature rise time (-18C/-9C) 9 Hours

Freezing capacity 15kg / 24 h

Climate class ** T/SN (10C - 43C)

Noise emission 41 dB(A)

Energy consumption of 297 kWh per year, calculated on the basis of results obtained in 24 hours under normalised test conditions. Real energy consumption depends on the conditions in which the equipment is used as well as where it is placed.

This appliance is designed for use at an ambient temperature within the 10C - 43C range.

26

If consultation or technical assistance is needed, please provide the local authorised service agent with the purchase invoice and the product code/serial number.

The 2 years free maintenance for the operation of the appliance started from the date of purchase of this product.

Any cosmetic damage to the appliance must be reported within 30 days of delivery.

Please note that AGA Rangemaster Limited have appointed Pacifica to administer in warranty repairs on our behalf. If you make a request for an in warranty repair, your details will be held by Pacifica

DocNo.111-0003 Warranty No.10 11. Warranty/After Sales Service

27

NOTE

28

NOTE

29

NOTE

Manualsnet FAQs

If you want to find out how the White Chrome Rangemaster works, you can view and download the Rangemaster Integrated RTFZ18 White Chrome User Guide on the Manualsnet website.

Yes, we have the User Guide for Rangemaster White Chrome as well as other Rangemaster manuals. All you need to do is to use our search bar and find the user manual that you are looking for.

The User Guide should include all the details that are needed to use a Rangemaster White Chrome. Full manuals and user guide PDFs can be downloaded from Manualsnet.com.

The best way to navigate the Rangemaster Integrated RTFZ18 White Chrome User Guide is by checking the Table of Contents at the top of the page where available. This allows you to navigate a manual by jumping to the section you are looking for.

This Rangemaster Integrated RTFZ18 White Chrome User Guide consists of sections like Table of Contents, to name a few. For easier navigation, use the Table of Contents in the upper left corner.

You can download Rangemaster Integrated RTFZ18 White Chrome User Guide free of charge simply by clicking the “download” button in the upper right corner of any manuals page. This feature allows you to download any manual in a couple of seconds and is generally in PDF format. You can also save a manual for later by adding it to your saved documents in the user profile.

To be able to print Rangemaster Integrated RTFZ18 White Chrome User Guide, simply download the document to your computer. Once downloaded, open the PDF file and print the Rangemaster Integrated RTFZ18 White Chrome User Guide as you would any other document. This can usually be achieved by clicking on “File” and then “Print” from the menu bar.