Mazda 6 2015 Scheduled Maintenance Manual PDF
Summary of Content for Mazda 6 2015 Scheduled Maintenance Manual PDF
Black plate (396,1)
Scheduled Maintenance (U.S.A., Canada, and Puerto Rico) Follow Schedule 1 if the vehicle is operated mainly where none of the following conditions apply. l Repeated short-distance driving l Driving in dusty conditions l Driving with extended use of brakes l Driving in areas where salt or other corrosive materials are used l Driving on rough or muddy roads l Extended periods of idling or low-speed operation l Driving for long periods in cold temperatures or extremely humid climates l Driving in extremely hot conditions l Driving in mountainous conditions continually If any do apply, follow Schedule 2 (Canada and Puerto Rico residents follow Schedule 2).
NOTE After the prescribed period, continue to follow the described maintenance at the recommended intervals.
6-4
Maintenance and Care
Scheduled Maintenance
Mazda6_8DQ8-EA-13L_Edition1 Page396 Monday, October 21 2013 1:49 PM
Form No.8DQ8-EA-13L
Black plate (397,1)
qSchedule 1
Maintenance Interval
Number of months or kilometers (miles), whichever comes first
Months 6 12 18 24 30 36 42 48
1000 km 12 24 36 48 60 72 84 96
1000 miles 7.5 15 22.5 30 37.5 45 52.5 60
ENGINE
Drive belts I
Engine oil R R R R R R R R
Engine oil filter R R R R R R R R
COOLING SYSTEM
Engine coolant FL22 type*1
Replace at first 192,000 km (120,000 miles) or 10 years; after that, every 96,000 km (60,000 miles) or 5 years
Others Replace at first 96,000 km (60,000 miles) or 4 years; after that,
every 2 years
FUEL SYSTEM
Air filter R
Fuel lines and hoses*2 I I
Hoses and tubes for emission*2 I
IGNITION SYSTEM
Spark plugs Replace every 120,000 km (75,000 miles)
CHASSIS and BODY
Brake lines, hoses and connections I I
Disc brakes I I I I
Tire (Rotation) Rotate every 12,000 km (7,500 miles)
Steering operation and linkages I I
Front and rear suspension, ball joints and wheel bearing axial play
I I
Driveshaft dust boots I I
Bolts and nuts on chassis and body T T
Exhaust system and heat shields Inspect every 72,000 km (45,000 miles) or 5 years
All locks and hinges L L L L L L L L
Maintenance and Care
Scheduled Maintenance
6-5
Mazda6_8DQ8-EA-13L_Edition1 Page397 Monday, October 21 2013 1:49 PM
Form No.8DQ8-EA-13L
Black plate (398,1)
Maintenance Interval
Number of months or kilometers (miles), whichever comes first
Months 6 12 18 24 30 36 42 48
1000 km 12 24 36 48 60 72 84 96
1000 miles 7.5 15 22.5 30 37.5 45 52.5 60
AIR CONDITIONER SYSTEM
Cabin air filter R R
Chart symbols:
I: Inspect: Inspect and clean, repair, adjust, fill up, or replace if necessary. R: Replace L: Lubricate T: Tighten
Remarks:
*1 Use FL22 type coolant in vehicles with the inscription FL22 on the radiator cap itself or the surrounding area. Use FL22 when replacing the coolant.
*2 According to state/provincial and federal regulations, failure to perform maintenance on these items will not void your emissions warranties. However, Mazda recommends that all maintenance services be performed at the recommended time or mileage/kilometer period to ensure long-term reliability.
6-6
Maintenance and Care
Scheduled Maintenance
Mazda6_8DQ8-EA-13L_Edition1 Page398 Monday, October 21 2013 1:49 PM
Form No.8DQ8-EA-13L
Black plate (399,1)
qSchedule 2
Maintenance Interval
Number of months or kilometers (miles), whichever comes first
Months 4 8 12 16 20 24 28 32 36 40 44 48
1000 km 8 16 24 32 40 48 56 64 72 80 88 96
1000 miles 5 10 15 20 25 30 35 40 45 50 55 60
ENGINE
Drive belts I
Engine oil Puerto Rico Replace every 5,000 km (3,000 miles) or 3 months
Others R R R R R R R R R R R R
Engine oil filter R R R R R R R R R R R R
COOLING SYSTEM
Engine coolant FL22 type*1
Replace at first 192,000 km (120,000 miles) or 10 years; after that, every 96,000 km (60,000 miles) or 5 years
Others Replace at first 96,000 km (60,000 miles) or 4 years; after that,
every 2 years
Engine coolant level I I I I I I I I I I I I
FUEL SYSTEM
Air filter Puerto Rico R R
Others R
Fuel lines and hoses*2 I I
Hoses and tubes for emission*2 I
IGNITION SYSTEM
Spark plugs Replace every 120,000 km (75,000 miles)
ELECTRICAL SYSTEM
Function of all lights I I I I I I I I I I I I
CHASSIS and BODY
Brake lines, hoses and connections I I
Brake and clutch fluid level I I I I I I I I I I I I
Disc brakes I I I I
Tire (Rotation) Rotate every 8,000 km (5,000 miles)
Tire inflation pressure and tire wear I I I I I I I I I I I I
Steering operation and linkages I I
Front and rear suspension, ball joints and wheel bearing axial play
I I
Driveshaft dust boots I I
Bolts and nuts on chassis and body T T
Body condition*3
(for rust, corrosion and perforation) I I I I
Exhaust system and heat shields Inspect every 72,000 km (45,000 miles) or 5 years
All locks and hinges L L L L L L L L L L L L
Washer fluid level I I I I I I I I I I I I
Maintenance and Care
Scheduled Maintenance
6-7
Mazda6_8DQ8-EA-13L_Edition1 Page399 Monday, October 21 2013 1:49 PM
Form No.8DQ8-EA-13L
Black plate (400,1)
Maintenance Interval
Number of months or kilometers (miles), whichever comes first
Months 4 8 12 16 20 24 28 32 36 40 44 48
1000 km 8 16 24 32 40 48 56 64 72 80 88 96
1000 miles 5 10 15 20 25 30 35 40 45 50 55 60
AIR CONDITIONER SYSTEM
Cabin air filter Replace every 40,000 km (25,000 miles) or 2 years
Chart symbols:
I: Inspect: Inspect and clean, repair, adjust, fill up, or replace if necessary. R: Replace L: Lubricate T: Tighten
Remarks:
*1 Use FL22 type coolant in vehicles with the inscription FL22 on the radiator cap itself or the surrounding area. Use FL22 when replacing the coolant.
*2 According to state/provincial and federal regulations, failure to perform maintenance on these items will not void your emissions warranties. However, Mazda recommends that all maintenance services be performed at the recommended time or mileage/kilometer period to ensure long-term reliability.
*3 Canada only.
6-8
Maintenance and Care
Scheduled Maintenance
Mazda6_8DQ8-EA-13L_Edition1 Page400 Monday, October 21 2013 1:49 PM
Form No.8DQ8-EA-13L
Black plate (401,1)
Scheduled Maintenance (Mexico) Follow Schedule 1 if the vehicle is operated mainly where none of the following conditions apply. l Repeated short-distance driving l Driving in dusty conditions l Driving with extended use of brakes l Driving in areas where salt or other corrosive materials are used l Driving on rough or muddy roads l Extended periods of idling or low-speed operation l Driving for long periods in cold temperatures or extremely humid climates l Driving in extremely hot conditions l Driving in mountainous conditions continually If any do apply, follow Schedule 2.
NOTE After the prescribed period, continue to follow the described maintenance at the recommended intervals.
Maintenance and Care
Scheduled Maintenance
6-9
Mazda6_8DQ8-EA-13L_Edition1 Page401 Monday, October 21 2013 1:49 PM
Form No.8DQ8-EA-13L
Black plate (402,1)
qSchedule 1
Maintenance Interval
Number of months or kilometers, whichever comes first
Months 6 12 18 24 30 36 42 48 54 60 66 72
1000 km 10 20 30 40 50 60 70 80 90 100 110 120
ENGINE
Drive belts I I I
Engine oil R R R R R R R R R R R R
Engine oil filter R R R R R R R R R R R R
COOLING SYSTEM
Cooling system I I I
Engine coolant FL22 type*1
Replace at first 200,000 km or 10 years; after that, every 100,000 km or 5 years
Others Replace every 2 years
FUEL SYSTEM
Air filter R R R R R R
Fuel lines and hoses I*2 I*2 I
Hoses and tubes for emission I*2 I*2 I
Fuel filter Replace every 60,000 km
IGNITION SYSTEM
Spark plugs Replace every 120,000 km
CHASSIS and BODY
Brake lines, hoses and connections I I I I I I
Brake and clutch fluid level I I I I I I I I I
Brake fluid R R R
Disc brakes I I I I I I I I I I I I
Tire (Rotation) Rotate every 10,000 km
Tire inflation pressure and tire wear I I I I I I I I I I I I
Steering operation and linkages I I I I I I I I I I I I
Front and rear suspension, ball joints and wheel bearing axial play
I I I I I I
Driveshaft dust boots I I I I I I
Bolts and nuts on chassis and body T T T T T T
Exhaust system and heat shields I I I I I I
All locks and hinges L L L L L L L L L L L L
Washer fluid level I I I I I I I I I I I I
6-10
Maintenance and Care
Scheduled Maintenance
Mazda6_8DQ8-EA-13L_Edition1 Page402 Monday, October 21 2013 1:49 PM
Form No.8DQ8-EA-13L
Black plate (403,1)
Maintenance Interval
Number of months or kilometers, whichever comes first
Months 6 12 18 24 30 36 42 48 54 60 66 72
1000 km 10 20 30 40 50 60 70 80 90 100 110 120
AIR CONDITIONER SYSTEM
Cabin air filter R R R
Chart symbols:
I: Inspect: Inspect and clean, repair, adjust, fill up, or replace if necessary. R: Replace L: Lubricate T: Tighten
Remarks:
*1 Use FL22 type coolant in vehicles with the inscription FL22 on the radiator cap itself or the surrounding area. Use FL22 when replacing the coolant.
*2 According to state/provincial and federal regulations, failure to perform maintenance on these items will not void your emissions warranties. However, Mazda recommends that all maintenance services be performed at the recommended time or kilometer period to ensure long-term reliability.
Maintenance and Care
Scheduled Maintenance
6-11
Mazda6_8DQ8-EA-13L_Edition1 Page403 Monday, October 21 2013 1:49 PM
Form No.8DQ8-EA-13L
Black plate (404,1)
qSchedule 2
Maintenance Interval
Number of months or kilometers, whichever comes first
Months 3 6 9 12 15 18 21 24 27 30 33 36
1000 km 5 10 15 20 25 30 35 40 45 50 55 60
ENGINE
Drive belts I
Engine oil R R R R R R R R R R R R
Engine oil filter R R R R R R R R R R R R
COOLING SYSTEM
Cooling system I
Engine coolant FL22 type*1
Replace at first 200,000 km or 10 years; after that, every 100,000 km or 5 years
Others Replace every 2 years
Engine coolant level I I I I I I I I I I I I
FUEL SYSTEM
Air filter C R C R C R
Fuel lines and hoses I*2
Hoses and tubes for emission I*2
Fuel filter Replace every 60,000 km
IGNITION SYSTEM
Spark plugs Replace every 120,000 km
ELECTRICAL SYSTEM
Function of all lights I I I I I I I I I I I I
CHASSIS and BODY
Brake lines, hoses and connections I I I
Brake and clutch fluid level I I I I I
Brake fluid R
Disc brakes I I I I I I
Tire (Rotation) Rotate every 10,000 km
Tire inflation pressure and tire wear I I I I I I
Steering operation and linkages I I I I I I
Front and rear suspension, ball joints and wheel bearing axial play
I I I
Driveshaft dust boots I I I
Bolts and nuts on chassis and body T T T
Exhaust system and heat shields I I I
All locks and hinges L L L L L L
Washer fluid level I I I I I I
6-12
Maintenance and Care
Scheduled Maintenance
Mazda6_8DQ8-EA-13L_Edition1 Page404 Monday, October 21 2013 1:49 PM
Form No.8DQ8-EA-13L
Black plate (405,1)
Maintenance Interval
Number of months or kilometers, whichever comes first
Months 3 6 9 12 15 18 21 24 27 30 33 36
1000 km 5 10 15 20 25 30 35 40 45 50 55 60
AIR CONDITIONER SYSTEM
Cabin air filter R R R
Chart symbols:
I: Inspect: Inspect and clean, repair, adjust, fill up, or replace if necessary. R: Replace L: Lubricate C: Clean T: Tighten
Remarks:
*1 Use FL22 type coolant in vehicles with the inscription FL22 on the radiator cap itself or the surrounding area. Use FL22 when replacing the coolant.
*2 According to state/provincial and federal regulations, failure to perform maintenance on these items will not void your emissions warranties. However, Mazda recommends that all maintenance services be performed at the recommended time or kilometer period to ensure long-term reliability.
Maintenance and Care
Scheduled Maintenance
6-13
Mazda6_8DQ8-EA-13L_Edition1 Page405 Monday, October 21 2013 1:49 PM
Form No.8DQ8-EA-13L
Black plate (406,1)
(Cont.)
Maintenance Interval
Number of months or kilometers, whichever comes first
Months 39 42 45 48 51 54 57 60 63 66 69 72
1000 km 65 70 75 80 85 90 95 100 105 110 115 120
ENGINE
Drive belts I I
Engine oil R R R R R R R R R R R R
Engine oil filter R R R R R R R R R R R R
COOLING SYSTEM
Cooling system I I
Engine coolant FL22 type*1
Replace at first 200,000 km or 10 years; after that, every 100,000 km or 5 years
Others Replace every 2 years
Engine coolant level I I I I I I I I I I I I
FUEL SYSTEM
Air filter C R C R C R
Fuel lines and hoses I*2 I
Hoses and tubes for emission I*2 I
Fuel filter Replace every 60,000 km
IGNITION SYSTEM
Spark plugs Replace every 120,000 km
ELECTRICAL SYSTEM
Function of all lights I I I I I I I I I I I I
CHASSIS and BODY
Brake lines, hoses and connections I I I
Brake and clutch fluid level I I I I
Brake fluid R R
Disc brakes I I I I I I
Tire (Rotation) Rotate every 10,000 km
Tire inflation pressure and tire wear I I I I I I
Steering operation and linkages I I I I I I
Front and rear suspension, ball joints and wheel bearing axial play
I I I
Driveshaft dust boots I I I
Bolts and nuts on chassis and body T T T
Exhaust system and heat shields I I I
All locks and hinges L L L L L L
Washer fluid level I I I I I I
6-14
Maintenance and Care
Scheduled Maintenance
Mazda6_8DQ8-EA-13L_Edition1 Page406 Monday, October 21 2013 1:49 PM
Form No.8DQ8-EA-13L
Black plate (407,1)
Maintenance Interval
Number of months or kilometers, whichever comes first
Months 39 42 45 48 51 54 57 60 63 66 69 72
1000 km 65 70 75 80 85 90 95 100 105 110 115 120
AIR CONDITIONER SYSTEM
Cabin air filter R R R
Chart symbols:
I: Inspect: Inspect and clean, repair, adjust, fill up, or replace if necessary. R: Replace L: Lubricate C: Clean T: Tighten
Remarks:
*1 Use FL22 type coolant in vehicles with the inscription FL22 on the radiator cap itself or the surrounding area. Use FL22 when replacing the coolant.
*2 According to state/provincial and federal regulations, failure to perform maintenance on these items will not void your emissions warranties. Howe
Related manuals for Mazda 6 2015 Scheduled Maintenance Manual
Manualsnet FAQs
If you want to find out how the Mazda 6 Mazda works, you can view and download the Mazda 6 2015 Scheduled Maintenance Manual on the Manualsnet website.
Yes, we have the Scheduled Maintenance Manual for Mazda Mazda 6 as well as other Mazda manuals. All you need to do is to use our search bar and find the user manual that you are looking for.
The Scheduled Maintenance Manual should include all the details that are needed to use a Mazda Mazda 6. Full manuals and user guide PDFs can be downloaded from Manualsnet.com.
The best way to navigate the Mazda 6 2015 Scheduled Maintenance Manual is by checking the Table of Contents at the top of the page where available. This allows you to navigate a manual by jumping to the section you are looking for.
This Mazda 6 2015 Scheduled Maintenance Manual consists of sections like Table of Contents, to name a few. For easier navigation, use the Table of Contents in the upper left corner.
You can download Mazda 6 2015 Scheduled Maintenance Manual free of charge simply by clicking the “download” button in the upper right corner of any manuals page. This feature allows you to download any manual in a couple of seconds and is generally in PDF format. You can also save a manual for later by adding it to your saved documents in the user profile.
To be able to print Mazda 6 2015 Scheduled Maintenance Manual, simply download the document to your computer. Once downloaded, open the PDF file and print the Mazda 6 2015 Scheduled Maintenance Manual as you would any other document. This can usually be achieved by clicking on “File” and then “Print” from the menu bar.