Carrier 30RAP070-150 Installation Instructions PDF

1 of 4
1 of 4

Summary of Content for Carrier 30RAP070-150 Installation Instructions PDF

Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations. Catalog No. 04-53090018-01 Printed in U.S.A. Form 09/30/38-12SI Pg 1 6-12 Replaces: 09/30/38-10SI

Installation Instructions Part No: 38AP-900---006; 38AP-900---007; 38AP-900---008;

38AP-900---026; 38AP-900---027; 38AP-900---028; 38AP-900---032; 38AP-900---033, 38AP-900---034

SAFETY CONSIDERATIONS When installing this accessory, observe precautions in the

literature and on any labels attached to the equipment, and all other safety precautions that may apply. Follow all safety codes. Wear safety glasses and work gloves. Use care in handling and installing this accessory.

INTRODUCTION This accessory package is intended for use with

09DPM065-130, 30RAP070-150, 38APD070-130, and 38APS065 units. See Table 1 for accessory package usage. The security grille/hail guard accessory helps prevent condenser coil damage. Refer to Table 2 for accessory package contents.

Table 1 Accessory Package Usage

Table 2 Accessory Package Contents

WARNING

Electrical shock can cause personal injury and death. Shut off all power to this equipment during installation. There may be more than one disconnect switch. Tag all discon- nect locations to alert others not to restore power until work is completed.

UNIT SIZE ACCESSORY PART NO. QTY USED

09DPM 30RAP 38APD,S 065,070 38AP-900---006 1 080-100 38AP-900---007 1 115,130 38AP-900---008 1

065 38AP-900---026 1 075-095 38AP-900---027 1 115,130 38AP-900---028 1

070-090 38AP-900---032 1 100-115 38AP-900---033 1 130-150 38AP-900---034 1

ACCESSORY PART NO.

ITEM NO. (QTY) PART NO. PART

DESCRIPTION

38AP-900---006

1 (4) 38AP503014 Louvered Panel

2 (2) 38AP503015 Louvered Panel

3 (4) 38AP503016 Wire Guard

5 (2) 38AP503021 Panel Support

6 (2) 38AP503022 Channel

7 (88) AL56ZA003 Screws

18 (32) AU02AB171 1/4-in. Flat Washer

19 (2) 38AP501877 Corner Support

38AP-900---007

1 (4) 38AP503014 Louvered Panel

2 (2) 38AP503015 Louvered Panel

3 (4) 38AP503016 Wire Guard

4 (2) 38AP503017 Wire Guard

5 (2) 38AP503021 Panel Support

6 (4) 38AP503022 Channel

7 (112) AL56ZA003 Screws

18 (48) AU02AB171 1/4-in. Flat Washer

19 (2) 38AP501877 Corner Support

38AP-900---008

1 (4) 38AP503014 Louvered Panel

2 (2) 38AP503015 Louvered Panel

3 (4) 38AP503016 Wire Guard

4 (4) 38AP503017 Wire Guard

5 (2) 38AP503021 Panel Support

6 (6) 38AP503022 Channel

7 (136) AL56ZA003 Screws

18 (64) AU02AB171 1/4-in. Flat Washer

19 (2) 38AP501877 Corner Support

09DPM065-130 30RAP070-150 38APD070-130

38APS065 Security Grille/Hail Guard Accessory

2

Table 2 Accessory Package Contents (cont) Table 2 Accessory Package Contents (cont)

INSTALLATION Refer to Tables 1 and 2 and inspect package contents for

any missing or damaged parts. File a claim with the shipping company if any item is missing or damaged, and notify your Carrier representative. See Fig. 1-4 for installation details. All parts are labeled. Be sure to check the part number on the label against the part description and part number listed in Table 2.

1. Disconnect all power to the unit. 2. Install the corner supports, Item 19, in the corner posts on

the end of the unit opposite the control box end. Use 4 screws, Item 7, per support.

3. Install support panels, Item 5, using screws provided. The 09DPM units use two support panels on the control box end, and one on the opposite end. The 38AP and 30RAP units use one support panel on each end.

4. On 09DPM units: Install louvered panels, Item 21, on control box end with screws provided. Install blockoff panel, Item 20, on control box end using screws provided.

ACCESSORY PART NO.

ITEM NO. (QTY) PART NO. PART

DESCRIPTION

38AP-900---026

1 (2) 38AP503014 Louvered Panel

2 (2) 38AP503015 Louvered Panel

3 (4) 38AP503016 Wire Guard

5 (3) 38AP503021 Panel Support

6 (2) 38AP503022 Channel

7 (102) AL56ZA003 Screws

18 (32) AU02AB171 1/4-in. Flat Washer

19 (2) 38AP501877 Corner Support

20 (1) 38AP501896 Blockoff Panel

21 (2) 38AP501803 Louvered Panel

38AP-900---027

1 (2) 38AP503014 Louvered Panel

2 (2) 38AP503015 Louvered Panel

3 (4) 38AP503016 Wire Guard

4 (2) 38AP503017 Wire Guard

5 (3) 38AP503021 Panel Support

6 (4) 38AP503022 Channel

7 (126) AL56ZA003 Screws

18 (48) AU02AB171 1/4-in. Flat Washer

19 (2) 38AP501877 Corner Support

20 (1) 38AP501896 Blockoff Panel

21 (2) 38AP501803 Louvered Panel

38AP-900---028

1 (2) 38AP503014 Louvered Panel

2 (2) 38AP503015 Louvered Panel

3 (4) 38AP503016 Wire Guard

4 (4) 38AP503017 Wire Guard

5 (3) 38AP503021 Panel Support

6 (6) 38AP503022 Channel

7 (150) AL56ZA003 Screws

18 (64) AU02AB171 1/4-in. Flat Washer

19 (2) 38AP501877 Corner Support

20 (1) 38AP501896 Blockoff Panel

21 (2) 38AP501803 Louvered Panel

38AP-900---032

1 (2) 38AP503014 Louvered Panel

2 (2) 38AP503015 Louvered Panel

3 (2) 38AP503016 Wire Guard

4 (1) 38AP503017 Wire Guard

5 (2) 38AP503021 Panel Support

6 (3) 38AP503022 Channel

7 (112) AL56ZA003 Screws

18 (54) AU02AB171 1/4-in. Flat Washer

19 (2) 38AP501877 Corner Support

22 (2) 38AP502095 Louvered Panel

23 (3) 38AP502981 Channel

24 (1) 38AP502612 Wire Guard

25 (1) 38AP503064 Wire Guard

26 (1) 38AP502609 Wire Guard

27 (1) 38AP502634 Wire Guard Patch

ACCESSORY PART NO.

ITEM NO. (QTY) PART NO. PART

DESCRIPTION

38AP-900---033

1 (2) 38AP503014 Louvered Panel

2 (2) 38AP503015 Louvered Panel

3 (3) 38AP503016 Wire Guard

4 (2) 38AP503017 Wire Guard

5 (2) 38AP503021 Panel Support

6 (5) 38AP503022 Channel

7 (112) AL56ZA003 Screws

18 (54) AU02AB171 1/4-in. Flat Washer

19 (2) 38AP501877 Corner Support

22 (2) 38AP502095 Louvered Panel

23 (3) 38AP502981 Channel

24 (1) 38AP502612 Wire Guard

25 (1)38AP504017 Wire Guard

26 (1) 38AP502609 Wire Guard

27 (1) 38AP502634 Wire Guard Patch

38AP-900---034

1 (2) 38AP503014 Louvered Panel

2 (2) 38AP503015 Louvered Panel

3 (4) 38AP503016 Wire Guard

4 (3) 38AP503017 Wire Guard

5 (2) 38AP503021 Panel Support

6 (7) 38AP503022 Channel

7 (170) AL56ZA003 Screws

18 (80) AU02AB171 1/4-in. Flat Washer

19 (2) 38AP501877 Corner Support

22 (2) 38AP502095 Louvered Panel

23 (3) 38AP502981 Channel

24 (1) 38AP503587 Wire Guard With Opening

25 (1)38AP504017 Wire Guard

26 (1) 38AP502609 Wire Guard

27 (1) 38AP502634 Wire Guard Patch

3

On 38AP units: Install louvered panels, Item 1, on control box end with screws provided. On 30RAP units: Install louvered panels, Item 22, on control box end with screws provided.

5. Install louvered panels, Item 1, on lower section of unit opposite the control box end using screws provided.

6. Install louvered panels, Item 2, on upper section of unit opposite the control box end using screws provided.

7. Install channel, Item 6, between each condenser "V" sec- tion using screws provided. On 30RAP units: Item 6 is installed the same as the above, except for the water connection point. Item 6 is not required at water connection point.

8. Install wire guards, Item 3, on outer "V" sections using flat washers and screws provided.

9. Install wire guards, Item 4, on inner "V" sections with flat washers and screws provided (all units except 09DPM065, 38APS065, and 38APD070). On 30RAP units: Item 4 is installed only on the non-water connection side.

10. 30RAP units only: Install wire guards, Items 24, 25, and 26, as shown on il- lustration, using screws provided. Install Item 23 between Items 25 and 26, below and above the water connection.

11. 30RAP units only: Install wire guards patch Item 27, over exposed water connection opening, using wire ties provided.

ITEM 3

ITEM 4

ITEM 3 ITEM 21

ITEM 20

ITEM 5

ITEM 3

ITEM 4

ITEM 3 ITEM 1

ITEM 19

ITEM 2

ITEM 5 ITEM 6

ITEM 6

ITEM 6

ITEM 6

OPPOSITE OF CONTROL BOX END CONTROL BOX END

Fig. 1 Security Grille/Hail Guard Installation 09DP Units (09DPM130 Unit Shown)

NOTES: 1. Item numbers refer to parts listed in Table 2. 2. All parts are labeled. Be sure to check the part number on the

label against the part description and part number listed in Table 2. a09-582

ITEM 3

ITEM 4

ITEM 3 ITEM 1

ITEM 5 ITEM 3

ITEM 4

ITEM 3 ITEM 1

ITEM 19

ITEM 2

ITEM 5ITEM 6

ITEM 6

ITEM 6

ITEM 6

OPPOSITE OF CONTROL BOX END CONTROL BOX END

Fig. 2 Security Grille/Hail Guard Installation 38AP Units (38APD115 Unit Shown)

NOTES: 1. Item numbers refer to parts listed in Table 2. 2. All parts are labeled. Be sure to check the part number on the

label against the part description and part number listed in Table 2. a09-583

Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations. Catalog No. 04-53090018-01 Printed in U.S.A. Form 09/30/38-12SI Pg 4 6-12 Replaces: 09/30/38/10SI

Copyright 2012 Carrier Corporation

ITEM 2

ITEM 1

ITEM 24

ITEM 26

ITEM 25

ITEM 23

ITEM 19

ITEM 5

ITEM 5

ITEM 22

ITEM 3

ITEM 6

ITEM 4

ITEM 3

ITEM 6

ITEM 6

OPPOSITE OF CONTROL BOX END

CONTROL BOX END

Fig. 3 Security Grille/Hail Guard Installation 30RAP070-090 Units (30RAP090 Unit Shown)

a30-5370

NOTES: 1. Item numbers refer to parts listed in Table 2. 2. All parts are labeled. Be sure to check the part number on the

label against the part description and part number listed in Table 2. 3. Item 27 not shown.

ITEM 2

ITEM 19

ITEM 5

ITEM 1 ITEM 3

ITEM 6

ITEM 24

ITEM 3

ITEM 6 ITEM 25

ITEM 23 ITEM 26

ITEM 3

ITEM 4 ITEM 6

ITEM 3 ITEM 22

ITEM 5

OPPOSITE OF CONTROL BOX END CONTROL BOX END

Fig. 4 Security Grille/Hail Guard Installation 30RAP100-150 Units (30RAP130 Unit Shown)

A30-5474

NOTES: 1. Item numbers refer to parts listed in Table 2. 2. All parts are labeled. Be sure to check the part number on the

label against the part description and part

Manualsnet FAQs

If you want to find out how the 30RAP070-150 Carrier works, you can view and download the Carrier 30RAP070-150 Installation Instructions on the Manualsnet website.

Yes, we have the Installation Instructions for Carrier 30RAP070-150 as well as other Carrier manuals. All you need to do is to use our search bar and find the user manual that you are looking for.

The Installation Instructions should include all the details that are needed to use a Carrier 30RAP070-150. Full manuals and user guide PDFs can be downloaded from Manualsnet.com.

The best way to navigate the Carrier 30RAP070-150 Installation Instructions is by checking the Table of Contents at the top of the page where available. This allows you to navigate a manual by jumping to the section you are looking for.

This Carrier 30RAP070-150 Installation Instructions consists of sections like Table of Contents, to name a few. For easier navigation, use the Table of Contents in the upper left corner.

You can download Carrier 30RAP070-150 Installation Instructions free of charge simply by clicking the “download” button in the upper right corner of any manuals page. This feature allows you to download any manual in a couple of seconds and is generally in PDF format. You can also save a manual for later by adding it to your saved documents in the user profile.

To be able to print Carrier 30RAP070-150 Installation Instructions, simply download the document to your computer. Once downloaded, open the PDF file and print the Carrier 30RAP070-150 Installation Instructions as you would any other document. This can usually be achieved by clicking on “File” and then “Print” from the menu bar.